How To Convert Honda Generator To Propane?

Propane / By

A propane conversion kit and a few tools are required to convert a Honda generator to propane. Then all you need is a day to finish it.

Even if you’ve already used gasoline in your Honda generator, you can convert it to propane. If you’ve previously used it with gas, all you have to do now is clean it. You may still use gas in your Honda generator with the Hutch Mountain conversion kit. This is a tri-fuel kit that includes gasoline, natural gas, and propane.

This kit takes roughly 45 minutes to convert your generator. The converting procedure is straightforward. Here’s a quick rundown:

  • Remove the engine’s front cover.
  • Drill a hole in the generator’s plastic housing.
  • The air filter should be removed.
  • Connect the propane line.
  • Your propane line should be connected.
  • Change the air filter.
  • Replace the cover and give it a try.

More information is available at: This is a quick rundown of the conversion procedure. For more information on how to convert your Honda generator to propane, read this article.

Is it possible to convert any generator to propane?

It’s pretty simple to convert your generator from gasoline to propane. Today’s market is flooded with DIY conversion kits. Some demand a significant amount of effort, while others only necessitate a few minor modifications.

The Hutch Mountain Generator Conversion Kit was chosen for this tour. Only a few tools and a rudimentary understanding of how to use them are required for this conversion kit. This is a very straightforward DIY project!

Converting Your Generator to Propane Step by Step:

  • Remove the engine’s front cover.
  • Mark a line from the air filter’s edge to the plastic generator case with tape. This will assist you in marking a hole for the propane line to be drilled.
  • Make a hole and drill it. Begin with a pilot bit, then use your step bit to enlarge the hole size to 9/16.
  • To remove the air filter assembly, remove the air filter cover and the three nuts that hold it in place.
  • Install the propane line according to the manufacturer’s instructions. Use the provided washers to route up through the hole you bore. Fit the elbow and quick connect fittings into place.
  • Connect the carburetor to the opposite end of the propane line using the provided gaskets.
  • Replace the air filter assembly with the spacer that comes with it.
  • Replace the air filter and the generator engine cover next.
  • Finally, use the sticker provided in your package to replace the factory operational sticker.

Is it possible to run a Honda generator on propane?

Yes, a Honda generator can be converted to run on propane. Conversion kits for propane generators are available from a variety of internet retailers. Propane conversion kits come in a variety of price ranges. The Honda EU2000i Propane, Natural Gas, and Gasoline Generator Tri-Fuel Kit from Hutch Mountain costs less than $300.

What is the cost of converting a generator to propane?

Natural gas isn’t mentioned as a generator fuel because it’s normally delivered by pipelines to homes, and many parts of the country aren’t connected to a natural-gas system. Although I had natural gas when I lived in Huntsville, I don’t have it now in Montgomery County. As a result, propane is my preferred fuel.

You can convert your generator to burn gas and propane or gas, propane, and natural gas with the help of conversion kits. A standard kit will cost around $200 and include everything you’ll need for the conversion.

I looked up conversion instructions online and watched YouTube videos of the process, and it appears that someone with a basic understanding of mechanics could complete the task with a few standard shop items.

Because you’re moving from gasoline to propane, start by cranking the generator and then closing the shut-off valve on the gas tank until the fuel in the line is depleted. Because there will be a small amount of gasoline left in the carburetor bowl, you can remove it and dump it.

The air cleaner must be removed first, and an adapter (venturi) with a propane fuel inlet must be installed on the bolts that link the air-cleaner base to the carburetor. Remounting the a/c will normally necessitate the use of a pair of bolt extender (included in the kit).

On 20lb propane, how long will a Honda generator run?

Generators utilize between two and three pounds of propane per hour on average. As a result, 20 pounds of propane can power a generator for an average of five hours.

Is it cheaper to use propane to power a generator?

In times of crisis, power generators can be quite useful. The most popular options are propane and gas generators, but which is better?

You most likely live in a house that is powered by electricity. Lights, refrigeration, heat, and television are all powered by the electric utility. While some things, like as live football, may be done without, other electrically driven goods are more necessary. If your major energy system fails, having a generator on standby might be highly beneficial. A generator is also essential for preppers who live off the grid or have a pre-determined bug-out destination.

When looking for a generator, there are two primary varieties to consider: propane and gas. We’ll go over the advantages and disadvantages of each choice to see which is the best.

Propane Generators

Propane generators work similarly to other generators in that they transform energy produced by propane burning into electricity. Propane is a by-product of the natural gas and petroleum refining industries. Propane generators are available in both standby and portable models, and can be used to power a variety of appliances and machinery.

Propane, when used as a generator fuel, can provide a number of critical advantages not seen in other types of generator fuel. Propane is a clean-burning gas with a long shelf life. A propane tank with a capacity of less than 100 pounds has an average expiration date of 12 years from the date of manufacturing. Once the tank has reached its expiration date, it must be replaced or evaluated to see whether re-qualification is possible, which might extend the tank’s life by another five years.

Another significant advantage of employing a propane generator is that the supply of propane will not be disturbed in the event of a natural disaster or other emergency. While you might expect the gas pumps to stop working within a short period of time, the propane supply should last considerably longer. Propane is kept in cylinders, making it not only easy to access but also to store for lengthy periods of time.

You can plan for the future, but you never know when or if you’ll need to use your generator. This means that your fuel could sit unused for years before you have a need for it. The fact that propane does not decay provides it an advantage over other fuels like gasoline and diesel. It will not become polluted if kept in its original tank. This enables the storage of bigger amounts of fuel without risk of it deteriorating or being polluted over time.

Propane is a low-noise fuel that is both clean and environmentally beneficial. The fuel burns cleanly, which means it creates less carbon monoxide (CO), which can cause suffocation in excessive volumes. Plants and other living animals can be harmed by carbon monoxide. Propane is significantly less damaging to individuals and the environment because of its low CO content.

Propane is often stored in bulk cylinders or safe tanks to avoid waste or spillage during storage and fill-ups. Propane is a safer alternative to gasoline, which is highly flammable and dangerous to store near a home. Propane, of course, should never be kept indoors. It should ideally be stored outdoors, away from any source of ignition, on a flat, non-flammable surface such as concrete.

While propane generators are one of the most environmentally friendly and long-lasting alternatives, they do have some drawbacks. Propane generators are more expensive than gasoline generators, which are more economical. Furthermore, propane generators are reported to produce up to 30% less heat than gasoline-powered devices. Propane generators are also larger than gasoline generators, which makes them more difficult to maneuver.

Gas Generators

Due to their effectiveness and cost, gasoline-powered generators remain one of the most common types of generators. An internal combustion engine drives a rotating shaft to turn an armature in a gas generator. The armature generates electromagnetic induction, which aids in the operation of the gasoline generator.

There are several advantages to using gas generators rather than propane generators. The cost of petrol is one of the most prominent reasons people pick it. Purchase and installation costs for gasoline generators are often substantially lower. Depending on the type and features, basic portable generators for usage at home or at camp sites can cost anywhere from $500 to $4,000 or more. It’s critical to pick a generator that can power all of the equipment you’ll need in an emergency.

A standby generator will cost between $300 and $500 per kilowatt, including installation. If you simply need a smaller unit, you should budget for a 12kW unit, which can cost anywhere from $4,000 to $6,000. You might expect to pay up to $20,000 or more for a larger 75kW unit.

In addition, gas generators produce more heat than propane generators, roughly 30% more for the same amount of fuel. Unless you reside in a location where propane is significantly less expensive than gasoline, a gas generator will almost always be less expensive to run. Gas generators are also more portable due to their smaller size. Unlike propane generators, which have tanks on the outside, gas generators have tanks on the inside, making them easier to maneuver.

Of course, there are some disadvantages to using a gas generator rather than a propane generator. When kept in a generator tank, gas, unlike propane, degrades with time. To maintain the fuel’s quality, it must be refilled on a regular basis. If you want to keep gasoline fresh, you should replace it at least every six months if it’s left in a generator or other tank.

Gas is also less environmentally friendly than propane. It has greater negative environmental consequences because it is a dirtier fuel. Before deciding on a fuel, this is a crucial factor to consider. In addition, gas generators are less convenient than propane generators. You will need to go to a gas station to purchase fuel for your gas-powered generator, as opposed to propane, which can be connected to a propane tank and is ready to use at any time. It may be difficult to locate and purchase fuel in the event of a crisis that impacts companies such as gas stations.

Choosing a Generator

Consider which elements of the fuel are more important to you when selecting a generator. If you’re on a limited budget and don’t mind replacing your fuel every now and again, an inexpensive gasoline generator might be the ideal option for you. A propane generator may be the best option if you like a fuel that does not degrade over time and are willing to pay a higher price for it.

Aside from deciding between a propane or gas-powered generator, there are a few more aspects to consider. These are some of them:

  • Starts automatically When the power goes off, an automated start generator will easily kick on. This is especially useful if you rely on your generator to keep vital machinery running at all times.
  • Start using an electric motor
  • If automatic starting isn’t required, an electric start can be a very convenient option. Your generator can start working with the push of a button if it has an electric start.
  • Fuel meter
  • The option to see how much fuel is left in your generator might be a useful function, especially during longer blackouts.
  • Several Outlets
  • Even if you don’t plan on plugging in too many things to your generator, having additional outlets can come in handy if the need arises.
  • Console that can be removed
  • A removable console can be an excellent safety feature, even if it isn’t required. You can plug in appliances without having to run extension cords outside thanks to a retractable console.

When the electricity goes out, having a generator on hand can help keep your home cool or warm, allow you to continue cooking, and keep vital equipment operating without interruption. Because no two generators are alike, it’s crucial to weigh all of the options and features to figure out which is the best fit for you. While there are various different types of generators, the most prevalent are propane and gas generators.

Some portable generators can run on both gasoline and propane, combining the affordability of gasoline with the convenience of propane. When faced with a crisis, though, having any option can be lifesaving.

How long can a generator run on a 20-pound propane tank?

A 20-pound propane tank will last roughly five hours when used to power a generator. This size propane tank can typically hold 4.6 gallons of propane. As a result, the working times may vary depending on the overall weight of your propane cargo.

What is the propane consumption of a Honda eu2200i?

If propane requires around 38% more fuel to match gasoline’s BTU output, and the Honda will operate for about 5.5 hours (using Honda’s average run duration), then the propane converted generator will burn about 1.3 gallons of propane in the same amount of time.

Is it better to use a propane or a gas generator?

Generator Efficiency: Propane compared. Gasoline Propane generators are inefficient, producing less BTUs per gallon of fuel than gas generators. Propane, on the other hand, burns cleaner than gasoline, making it better for the environment as well as your generator.